Heat Controller, Inc. • 1900 Wellworth Ave. • Jackson, MI 49203 • (517)787-2100 • www.heatcontroller.comINSTALLATION, OPERATION & MAINTENANCE MANU
9Installation & Operation WATER-TO-WATER (HWW) SERIES Heat Controller, Inc.Water-Loop Heat Pump ApplicationsCommercial systems typically include
10Heat Controller, Inc. WATER-TO-WATER (HWW) SERIES Installation & Operation Ground-Water Heat Pump ApplicationsTypical open loop piping is show
11Installation & Operation WATER-TO-WATER (HWW) SERIES Heat Controller, Inc.Ground-Water Heat Pump ApplicationsIn areas with extremely hard wate
12Pre-InstallationPrior to installation, locate and mark all existing underground utilities, piping, etc. Install loops for new construction before si
13Installation & Operation WATER-TO-WATER (HWW) SERIES Heat Controller, Inc.Air Pad or Extruded polystyrene insulation board Unit Power Discon
14Heat Controller, Inc. WATER-TO-WATER (HWW) SERIES Installation & Operation Electrical-Line VoltageHWW Electrical DataGeneral Line Voltage Wiri
15Installation & Operation WATER-TO-WATER (HWW) SERIES Heat Controller, Inc.Electrical-AccessoriesAccessory ConnectionsA terminal paralleling th
16Heat Controller, Inc. WATER-TO-WATER (HWW) SERIES Installation & Operation Electrical-Line VoltageAll eld installed wiring, including electri
17Installation & Operation WATER-TO-WATER (HWW) SERIES Heat Controller, Inc.Electrical-Low VoltageThermostat ConnectionsThe aquastat/thermostat
18Heat Controller, Inc. WATER-TO-WATER (HWW) SERIES Installation & Operation Typical Wiring Diagram Three Phase: HWW120 Units with CXM Controlle
1Model Nomenclature ...2Storage ...
19Installation & Operation WATER-TO-WATER (HWW) SERIES Heat Controller, Inc.Typical Wiring Diagram Single Phase: HWW036-060 Units with CXM Contr
20Heat Controller, Inc. WATER-TO-WATER (HWW) SERIES Installation & Operation CXM Controls:For detailed control information, see the CXM Applicat
21Safety Features: CXM ControlsThe safety features below are provided to protect the com-pressor, heat exchangers, wiring and other components from da
22Heat Controller, Inc. WATER-TO-WATER (HWW) SERIES Installation & Operation Safety Featuresc) In cooling mode with compressor energized, FP2 i
23Installation & Operation WATER-TO-WATER (HWW) SERIES Heat Controller, Inc.Piping Systems Cleaning & FlushingCleaning and ushing of the WL
24Heat Controller, Inc. WATER-TO-WATER (HWW) SERIES Installation & Operation Unit & System CheckoutUNIT CHECKOUTq Balancing/Shutoff Valves:
25Installation & Operation WATER-TO-WATER (HWW) SERIES Heat Controller, Inc.Unit Start Up ProceduresTable 5: Water Temperature Change Through So
26Heat Controller, Inc. WATER-TO-WATER (HWW) SERIES Installation & Operation Unit Start Up ProcedureTable 6: Coax Water Pressure Drop HWW036-120
27Installation & Operation WATER-TO-WATER (HWW) SERIES Heat Controller, Inc.Operating PressuresTMW036-120 (TMW120 Per Circuit) (60 Hz I-P Units)
28Heat Controller, Inc. WATER-TO-WATER (HWW) SERIES Installation & Operation Operating PressuresTMW036-120 (TMW120 Per Circuit) (60 Hz I-P Units
2Heat Controller, Inc. WATER-TO-WATER (HWW) SERIES Installation & Operation Page 217 May, 2009HEAT CONTROLLER OEM PRICE LISTHWW HIGH EFFICIENCY
29Preventative MaintenanceHeat Exchanger Maintenance – (Direct Ground Water Applications Only)If the installation is performed in an area with a kn
30:etaD putratS:epyT pooL:remotsuCModel #::% & epyT ezeerfitnA:# laireSComplaint:VoltageCompressor Amps1 Suction Temp2 Suction Press2a Saturation
04/200911/2010
3Installation & Operation WATER-TO-WATER (HWW) SERIES Heat Controller, Inc.General Information� WARNING! �� WARNING! �� CAUTION! �SafetyWarnings
4Heat Controller, Inc. WATER-TO-WATER (HWW) SERIES Installation & Operation General InformationInspectionUpon receipt of the equipment, carefull
5Installation & Operation WATER-TO-WATER (HWW) SERIES Heat Controller, Inc.Unit Physical DataModel 036 060 120Compressor (qty) Scroll (1) Scroll
6Heat Controller, Inc. WATER-TO-WATER (HWW) SERIES Installation & Operation Unit Dimensional Data: HWW 036–120BCAMLK1.0(2.5 cm)123456JHGFED12345
7Installation & Operation WATER-TO-WATER (HWW) SERIES Heat Controller, Inc.Unit InstallationHWW Unit LocationThese units are not designed for ou
8Heat Controller, Inc. WATER-TO-WATER (HWW) SERIES Installation & Operation Load Plumbing InstallationHWW Unit Load PlumbingThe applications are
Commentaires sur ces manuels